Pennwest Homes Custom Cabinets Face Frames

The fronts of our certified cabinets are precision-cut and use pocket-screws on a specialized table for a tight, consistent fit.

Pennwest Homes Custom Cabinets Pocket Screw System Close-Up

Close-up of the pocket-screw system to hold the front together

Pennwest Homes Custom Cabinets Back Screw

The entire cabinet is constructed using hot cabinet glue with pre-grooved panels and fronts. The entire box is then held square with clamps. We do not use 'cleats' to build cabinets, typically found in very low-end cabinets.

Pennwest Homes Custom Cabinets Extra Strength Base Cabinet

Extra strength is also added behind the overhead cabinets

Pennwest Homes Custom Cabinets Dadoed Back

Extra strength is also added behind the overhead cabinets

Pennwest Homes Custom Cabinets Modular Cabinets Extra Strength

Pennwest cabinets are built as components. This means longer countertops will sit on multiple individual cabinets, rather than one long cabinet. This extra strength means longer-lasting countertops.

Pennwest Homes Custom Cabinetst Dove Tail Drawers

All of our kitchen and bath drawers are built true dove-tail construction

Pennwest Homes Custom Cabinets Dove Tail Drawer Ball Bearing Guides

Many of our homes include 75-pound ball-bearing Kitchen drawer guides as standard, and is optional on all others. Others may also offer ball-bearing guides, but often use lower-end 40-pound or lighter guides.

Pennwest Homes Custom Cabinets Deep Drawers

Our kitchen drawers are full-length - 20" typically. This is longer than most, and allows you more flexbility in organizing your drawers.

Pennwest Homes Custom Cabinets Adjustable Overhead Cabinet Shelves

Pennwest uses 3/4" adjustable shelves with finished edges in our overhead cabinets. This is a heavier-duty shelf, the can be adjusted to fit your plates, glasses, and anything else.

Pennwest Homes Custom Cabinets Adjustable Base Cabinet Shelves

Pennwest uses 3/4" adjustable half-shelf in the kitchen base cabinets. This allows you to accommodate cereal boxes, pitchers. or anything else you would store below.

Pennwest Homes Custom Cabinets Hidden Hinges

We use hidden hinges on cabinets.

Pennwest Homes Custom Cabinets Recessed Toe-Kick

Our base cabinets include a recessed toe-kick for ease of working.

Pennwest Homes Custom Cabinets Heavy Cabinet

Our cabinets are heavy. They are built to last. A typical wood overhead cabinet - before doors are even attached - weighs over 30 pounds.

Even our kitchen island countertops even use a double substrate for greater strength. We know families and friends often gather at the kitchen island.

 

 

 

 

Pennwest Homes understands that your kitchen is an important place for you and your family. A cornerstone of a good kitchen is the cabinetry. It should look good, perform over time, and adjust to your changing needs. Quality cabinets are a trademark of Pennwest. EVERMORE Custom Cabinets, our factory-crafted KCMA-certified cabinets, are strong, good-looking, and built to last.

All of our cabinets are built to the rigorous performance standards of the Kitchen Cabinet Manufacturers Association. This KCMA label is the same as you'll find in many of the best store-purchased or custom-built cabinets. If your kitchen is important to you, then why would you want an inferior cabinet?

Simply put, our cabinets are heavier, stronger, and squarer. We even build them with dovetail construction. Our cabinets need to pass many tests, including:

Our cabinets are regulary (and randomly) tested by authorized third-parties.

Through on-going tests performed by an experienced, independent laboratory, the KCMA certification program assures you that any cabinet bearing the blue and white KCMA seal complies with the rigorous standards set by the American National Standards Institute (ANSI) and KCMA.

Check out our Evermore Custom Cabinet Brochure for more details!
 

Header05